geopolymer concrete with quarry dust

geopolymer concrete with quarry dust

Physical Properties of GeoPolymer Concrete with Quarry ...

The main part of this work aimed at characterizing the engineering strength properties of geopolymer concrete by 100% replacement of fine aggregate with quarry rock dust.

Investigating Strength Properties of Geopolymer Concrete ...

To address the environmental constraints due to cement production and sand scarcity, strength properties of high-calcium fly ash (CFA)-based geopolymer concrete with quarry dust as fine aggregate ...

Investigating Strength Properties of Geopolymer Concrete ...

2017-5-1 · Date: 5/1/2017. Abstract: To address the environmental constraints due to cement production and sand scarcity, strength properties of high-calcium fly ash (CFA)-based geopolymer concrete with quarry dust as fine aggregate is explored in this paper. River sand was replaced with quarry dust from 0 to 100% by mass.

Mechanical and Microstructural Characterization of Quarry ...

2021-11-15 · The purpose of this research is to study the effects of quarry rock dust (QRD) and steel fibers (SF) inclusion on the fresh, mechanical, and microstructural properties of fly ash (FA) and ground granulated blast furnace slag (SG)-based geopolymer concrete (GPC) exposed to elevated temperatures. Such types of ternary mixes were prepared by blending waste materials from different industries ...

Compressive strength study of Geopolymer Mortar using ...

2021-11-23 · Quarry Rock Dust can be defined as residue, tailing or other non-voluble waste material after the extraction and processing of rocks to form fine particles less than 4.75 mm. This article presents the feasibility of the usage of Quarry Rock Dust as a substitute for Natural Sand in geopolymer mortar.

Triaxial and density behaviour of quarry dust based ...

2019-4-18 · The effect of quarry dust based geopolymer cement (QDbGPC) and crushed waste glasses (CWG) on the triaxial and density characteristics of expansive test soil was investigated under laboratory conditions. Quarry dust is a solid waste the management of which poses a big problem to construction and environmental experts. So also is the management of waste glasses. Then again, the use

Investigation of usability of quarry dust waste in fly ash ...

2019-8-30 · Quarry dust (QD) was used as mineral filler. Table 1 shows the XRF results. The QD consists mainly of CaO and has a specific gravity of 2.6 and a specific surface of 0.23 m 2 /g. According to the XRD results (), the QD is predominantly composed of calcite mineral as well as dolomite, carbon and other minerals.NaOH and Sodium Silicate (SS) were used in the preparation of the geopolymer

Dolomite-based quarry-dust as a substitute for fly-ash ...

2019-10-20 · Quarry dust was acquired from a local construction-oriented quarrying company and integrated into both the geopolymer and cement-based systems. Raw QD was pre-processed by air-drying in an oven at 105 °C for 24 h and then manually ground using pestle and mortar, to obtain an average particle size of 90 μm.

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5 · cement industries use fly ash to improve the volume. quarry dust also contains a similar property of river sand. quarry dust is used in concrete to minimize the demand of river sand. maximum exploitation of sand is to be minimized to protect the river beds, shore structures from erosion. to reduce disposal and pollution problems emanating from ...

Physical Properties of GeoPolymer Concrete with Quarry ...

The main part of this work aimed at characterizing the engineering strength properties of geopolymer concrete by 100% replacement of fine aggregate with quarry rock dust.

PERFORMANCE EVALUATION OF AMBIENT CURED

2021-8-24 · Abstract- Geopolymer concrete (GPC) an alternative of Ordinary Portland Cement concrete (OPC) is prepared by mixing three waste/by-products that are Fly-ash (FA), ground granulated blast furnace slag (GBS) and quarry rock dust (QRD) at the rate of 50%, 35% and 15% of binder respectively. Since GPC has gained interest of many

An Experimental Study of Fibre Reinforced Geo Polymer ...

2019-7-1 · Polymer Concrete using Fly ash, GGBS and Polypropylene Fibres with a Partial Replacement of Normal Sand by Quarry Dust . Manjunatha M Katti . Assistant Professor, Dept of Civil Engineering, Channabasaveshwara Institute of Technology, Gubbi, Tumakuru, Karnataka, India .

Investigation of usability of quarry dust waste in fly ash ...

2019-8-30 · Quarry dust (QD) was used as mineral filler. Table 1 shows the XRF results. The QD consists mainly of CaO and has a specific gravity of 2.6 and a specific surface of 0.23 m 2 /g. According to the XRD results (), the QD is predominantly composed of calcite mineral as well as dolomite, carbon and other minerals.NaOH and Sodium Silicate (SS) were used in the preparation of the geopolymer

Triaxial and density behaviour of quarry dust based ...

2019-4-18 · The effect of quarry dust based geopolymer cement (QDbGPC) and crushed waste glasses (CWG) on the triaxial and density characteristics of expansive test soil was investigated under laboratory conditions. Quarry dust is a solid waste the management of which poses a big problem to construction and environmental experts. So also is the management of waste glasses. Then again, the use

Production of geopolymer concrete by utilizing volcanic ...

Geopolymer concrete with OPC and CKD as partial replacement of 30% by weight of VPD achieved an increase of 23% and 8%, respectively, in compressive strength at a test age of 90 days. Meanwhile, 20% VPD replacement by CKD achieved 11% higher compressive strength for the VPD–CKD samples compared with the control mixture.

Strength Studies On Geo-Polymer Concrete by using Fly

2019-4-22 · Geopolymer concrete is such a one and in the present study, to produce the geo-polymer concrete the Portland cement is fully replaced with fly ash and the fine aggregate is replaced with quarry dust and alkaline liquids are used for the binding of materials. The alkaline liquids used in this study for the polymerization are the solutions of ...

SOIL STABILIZATION USING GEOPOLYMER AND

2019-11-15 · Stabilization using quarry dust The quarry dust/ crusher dust obtained during crushing of stone to obtain aggregates causes health hazard in the vicinity and many times considered as an aggregate waste. Stalin et al. (2004) made an investigation regarding control of swelling potential (SP)of expansive clays using quarry dust

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5 · cement industries use fly ash to improve the volume. quarry dust also contains a similar property of river sand. quarry dust is used in concrete to minimize the demand of river sand. maximum exploitation of sand is to be minimized to protect the river beds, shore structures from erosion. to reduce disposal and pollution problems emanating from ...

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28 · The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

An Explorative Study On Quarry Dust Blended Geo

2019-11-20 · geopolymer concrete cured in ambient condition, Construction Building Materials, 66 (2014) 163-171. [3] Deb P, Nath P, Sarker PK. The effects of ground granulated blast-furnace slag blending with fly ash and activator content on the workability and strength properties of geopolymer concrete cured at ambient temperature,

PERFORMANCE EVALUATION OF AMBIENT CURED

2021-8-24 · Abstract- Geopolymer concrete (GPC) an alternative of Ordinary Portland Cement concrete (OPC) is prepared by mixing three waste/by-products that are Fly-ash (FA), ground granulated blast furnace slag (GBS) and quarry rock dust (QRD) at the rate of 50%, 35% and 15% of binder respectively. Since GPC has gained interest of many

An Experimental Study of Fibre Reinforced Geo Polymer ...

2016-11-5 · An Experimental Study of Fibre Reinforced Geo Polymer Concrete using Fly ash, GGBS and Polypropylene Fibres with a Partial Replacement of Normal Sand by Quarry Dust - written by Manjunatha M Katti, Bharath Kumar N, Brahmananda Goutham published on 2016/05/11 download full article with reference data and citations

An Experimental Study of Fibre Reinforced Geo Polymer ...

2019-7-1 · Polymer Concrete using Fly ash, GGBS and Polypropylene Fibres with a Partial Replacement of Normal Sand by Quarry Dust . Manjunatha M Katti . Assistant Professor, Dept of Civil Engineering, Channabasaveshwara Institute of Technology, Gubbi, Tumakuru, Karnataka, India .

Published Online March 2020 in IJEAST (ijeast ...

2020-4-10 · quarry dust with consequent disposal and pollution problem. Need for geopolymer concrete (GPC) The Geopolymer technology was first introduced by Davidovits in 1978 along with the geopolymer binders. His work considerably shows that the adoption of the geopolymer technology could reduce the CO 2. Emission caused by cement industries.

SOIL STABILIZATION USING GEOPOLYMER AND

2019-11-15 · Stabilization using quarry dust The quarry dust/ crusher dust obtained during crushing of stone to obtain aggregates causes health hazard in the vicinity and many times considered as an aggregate waste. Stalin et al. (2004) made an investigation regarding control of swelling potential (SP)of expansive clays using quarry dust

Case Study of Geopolymer Concrete with Properties

2021-4-9 · Geopolymer concrete is such a one and in the present study, to produce the geo-polymer concrete the Portland cement is fully replaced with fly ash and Ground granulated blast-furnace slag. Fine aggregate is replaced with quarry dust and M.Sand. Coarse Aggregate (20mm) are replaced with 10mm Aggregate Alkaline liquids are

Strength Studies On Geo-Polymer Concrete by using Fly

2019-4-22 · Geopolymer concrete is such a one and in the present study, to produce the geo-polymer concrete the Portland cement is fully replaced with fly ash and the fine aggregate is replaced with quarry dust and alkaline liquids are used for the binding of materials. The alkaline liquids used in this study for the polymerization are the solutions of ...

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%. International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 2 ISSN 2250-3153 ijsrp.org B. Casting of specimen Mould of size 150 x 150 x 150 mm was used to cast specimens ...

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5 · cement industries use fly ash to improve the volume. quarry dust also contains a similar property of river sand. quarry dust is used in concrete to minimize the demand of river sand. maximum exploitation of sand is to be minimized to protect the river beds, shore structures from erosion. to reduce disposal and pollution problems emanating from ...